You are here:

4 Wheel Drive/SUVs/saab 97x New Venture 126 transfer case

Advertisement

Expert: - 12/16/2010


Question
1) is there any to install an override switch to feed power to the transfer case encoder motor to lock the awd system in awd? the way it engages/disengages is terrible.
OR: will the torsen transfer case from a Trailblazer SS fit?

Answer
Casey,
I'm not familiar with that transfer case, but you can contact Advance Adapters to see what might be available for a conversion.  I have a 2003 Grand Cherokee with AWD.  It works great and is extremely smooth.

I would suspect that you are having an internal problem with the transfer case.  I would change out the fluid first and see if this helps.  If not I would consider talking to some one else who owns a similar vehicle to see if they are having the same problems.

Carl

www.advanceadapters.com

Phone & Fax
Toll Free: 1-800-350-2223
Local: 805-238-7000
Fax: 805-238-4201

Mailing Address    
P.O Box 247              
Paso Robles, California    
93447    

Physical Address
4320 Aerotech Center way
Paso Robles, California
93446

4 Wheel Drive/SUVs

All Answers

Answers by Expert:

Ask Experts

Volunteer

Carl Brandt

Expertise

Will discuss suspensions, lifts, lockers along with tire suggestions. Trail ratings and possible requirements needed for specific type of trails. Safety equipment and what you should carry with you. Certified off-road instructor. I am not a mechanic, and 4-Wheeling is a hobby, so if I can't answer a technical question it is due to my mechanical knowledge being related to vehicles that I have owned, or have worked on. I do not have manuals on all vehicles.

Experience

40 plus years of 4 wheeling in a variety of vehicles. At the present time, my major off-road rig is a 94 Jeep Wrangler with a spring over and a 1 1/2" suspension lift. This gives me a total lift of 7" or so. I have lockers front and rear. I have removed the track bars, and sway bar for maximum articulation. I am running a stock 2.5 ltr 4 cylinder with a Jacobs ignition along with a cold air high flow filter. It has 4.56:1 gears with a Dodge NV4500 transmission along with a 3.8:1 Atlas II transfer case. This gives me a final ratio of 105:1 in low gear/low range. Other vehicles I own, are a 96 Ford F-250 with a 6" lift, posi rear end, 36" Hummer tires, 5 speed with a fuel injected 460 ci engine, an 87 Samurai with an 8" lift, Ford 9" rear end with a spool, Chevy Dana 44 front end with an electric locker, 5.88 gears, 16% reduction in high range and a 6.5:1 low range with 35" Baja Claws, and a stock 2003 Grand Cherokee Overland. Trails I have run are the Rubicon (10 times), Dusey Ershim, Fordyce Creek trail, McGrew trail, several trails in Moab, Utah along with local monthly runs.

Organizations
Lost Coast 4x4's Cal 4-Wheel Corva UFWDA Blue Ribbon Coalition

Education/Credentials
Certified off-road instructor - Certificates in engineering/electronics

©2012 About.com, a part of The New York Times Company. All rights reserved.