Question My 1998 Jeep had its AC compressor changed in June 06. Worked fine for about 6 months. Stopped engaging. Had the system recharged with dye. Drove it home about six miles, seemed OK. Did not run Jeep for two days. Two days later I noticed the compressor wasn't engaging. Took it back for the UV light check for the dye. No leaks were found. They tell me now my evaporator core (under dash)is leaking. Will replace for $700. The compressor doesn't engage but the system seems to have a charge (determined by pushing down the fill stem.) Does this sound plausible and could it be something else? Thanks
Answer Hi William,
Absolutely plausible. The A/C system can still have pressure in it, and yet be too low to engage the compressor. The low-pressure cut-off switch will prevent compressor clutch engagement to protect the compressor in the event of a low refrigerant charge, and this condition is normal. The system can still contain some refrigerant (noticeable at the service ports), and will even seem to have a charge with only residual refrigerant (essentially, empty) when pushing down on the schrader valve at the service port.
When checking the system with dye, it's often easy to verify the leak by shining the UV light on the HVAC case drain tube. Often times, though, nothing is evident at the drain, and you only notice the leak when the HVAC case is removed and the evaporator inspected (the evaporator is not visible without pulling the dash and HVAC case). I've pulled plenty of these apart, after the UV showed nothing visible *anywhere*, only to find out that the evaporator is green (with fluorescent dye).
The cost seems a bit high, but in HVAC system repair, you often get what you pay for. $700, while expensive, is about normal for the dealer, and it's the hardest component to replace in the A/C system.
